Air Operating Permit - Puget Sound Clean Air Agency

More documents

Recommendations

Info

II. MONITORfNG, MAINTENANCE, AND RECORD KEEPING Permit No. 13120Expiration Date: September 12, 2013Page 212 of2910) Averaging Scheme/or Exterior Commercial Primer and Topcoat1. Boeing may use any combination of uncontrolled primers, including waterborneprimers, at one or more emission units, within that same facility, where aerospaceexterior commercial priming operations occur that are subject to 40 CFR63.745(c), provided that:(a) The monthly volume-weighted average organic HAP content of the combinationof exterior commercial primers does not exceed 650 g/liter (less water); and(b) The monthly volume-weighted average VOC content of the combination ofexterior commercial primers does not exceed 650 g/liter (less water and exemptsolvents).[40CFR 63.752(c)(4), 9/1/98]2. (a) Doeing shall maintain records of the monthly volume-weighted average mass oforganic HAP emitted per Wlit volume of primer as applied (less water) (Ha) for allexterior commercial primers for which averaging is used to meet the HAP contentlimit (as determined by the procedures specified in 40 CFR 63.750(d»; and alldata and calculations used to determine Ha for each emission wlit for whichBoeing wishes to use this averaging scheme to demonstrate compliance with theHAP content limit. [40CFR 63.752(c)(4), 9/1/98](b) Boeing shall maintain records of the monthly volume-weighted average mass ofVOC emitted per unit volume of primer as applied (less water and exemptsolvents) (Ga) for all exterior commercial primers for which averaging is used tomeet the VOC content limit (as determined by the procedures specified in 40 CFR63.750(f); and all data and calculations used to determine Ga for each emissionunit for which Boeing wishes to use this averaging scheme to demonstratecompliance with the VOC content limit. [40CFR 63.752 (c)(4), 9/1/98](c) If before the beginning of any calendar month Boeing enters into a log that aspecific emission unit or units will only use exterior commercial primers withorganic HAP content that does not exceed 650 g/liter (less water) and makes thatBoeing-Everett Permit, issued September 12, 2008,. Administrative Amendment 3: October 10, 2012
II. MONITORING, MAINTENANCE, AND RECORDKEEPING Permit No. 13120Expiration Date: September 12, 2013Page 213 of291log available to Puget Sound Clean Air Agency personnel upon request, thenBoeing does not need to follow Condition No. 2(a) for that month or months.[WAC 173-401-650(1), 1114/93](d) If before the beginning of any calendar month Boeing enters into a log that aspecific emission unit or units will only use exterior commercial primers withVOC content that does not exceed 650 glliter (less water and exempt solvents)and makes that log available to Puget Sound Clean Air Agency personnel uponrequest, Boeing does not need to follow Condition No. 2(b) for that month ormonths. [WAC 173·401-650(1), 1114/93](k) Notice of CompletionBoeing submitted a Notice of Completion to the Puget Sound Clean Air Agency statingthat the work covered by a Notice of Construction application had been completed andoperation was ready to begin. Boeing will not change the equipment in a manner thatrequires an NOC Order of Approval without first obtaining an Order of Approval.[WAC 173-401-615(1)(b), 10117/02](/) Aerospace NESHAP Depainting Monitoring and RecordkeepingProcedureThe following monitoring and recordkeeping requirements apply if Boeing Everettdepaints more than six completed aircraft in a calendar year. An aircraft is counted asdepainted if it has all the fuselage, wings, vertical stabilizers and horizontal stabilizersconnected as one assembled unit and has had paint chemically removed fromsubstantially all of the outer surface of either the fuselage, or wings, or horizontalstabilizers, or vertical stabilizers.(i) For sources complying with 40 CFR 63.746(b)(3), must determine volume oforganic HAP-containing chemical strippers or alternatively the weight of organicHAP used per aircraft using the procedures specified in 40 CFR 63.7500)(1)through (3). [40 CFR 63.7500), 10117/00](ii) For all chemical strippers used in depainting operations subject to 40 CFR 63.746,Boeing-Everett Permit, issued September J 2, 2008,' Administrarive Amendment 3: October 10, 2012
Page 1 and 2:
AIR OPERATING PERMITpscleanair.orgP
Page 3 and 4:
Permit No. 13120Expiration Date: Se
Page 5 and 6:
Permit No. 13120Expiration Date: Se
Page 7 and 8:
Facility-Wide Applicable Requiremen
Page 9 and 10:
Page 11 and 12:
Page 14 and 15:
Page 16 and 17:
PennitNo.13120EMISSION UNIT SPECIFI
Page 18 and 19:
EMISSION UNIT SPECIFIC REQUIREMENTS
Page 20 and 21:
Page 22 and 23:
Page 24 and 25:
Page 26 and 27:
Page 28 and 29:
Page 30 and 31:
Page 32 and 33:
Page 34 and 35:
Page 36 and 37:
Page 38 and 39:
Page 40 and 41:
Page 42 and 43:
Page 44 and 45:
Page 46 and 47:
Page 48 and 49:
Page 50 and 51:
Page 52 and 53:
Page 54 and 55:
Page 56 and 57:
Page 58 and 59:
Page 60 and 61:
Page 62 and 63:
Page 64 and 65:
Page 66 and 67:
Page 68 and 69:
Page 70 and 71:
Page 72 and 73:
Page 74 and 75:
Page 76 and 77:
Page 78 and 79:
Page 80 and 81:
Page 82 and 83:
Page 84 and 85:
Page 86 and 87:
Page 88 and 89:
Page 90 and 91:
Page 92 and 93:
Page 94 and 95:
Page 96 and 97:
Page 98 and 99:
Page 100 and 101:
Page 102 and 103:
Page 104 and 105:
Page 106 and 107:
Page 108 and 109:
Page 110 and 111:
Page 112 and 113:
Page 114 and 115:
Page 116 and 117:
Page 118 and 119:
Page 120 and 121:
Permit No. 13120EMISSION UNIT SPECI
Page 122 and 123:
Page 124 and 125:
Page 126 and 127:
Page 128 and 129:
Page 130 and 131:
Page 132 and 133:
Page 134 and 135:
Page 136 and 137:
Page 138 and 139:
Page 140 and 141:
Page 142 and 143:
Page 144 and 145:
Page 146 and 147:
Page 148 and 149:
Page 150 and 151:
Page 152 and 153:
Page 154 and 155:
Page 156 and 157:
Page 158 and 159:
Page 160 and 161:
Page 162 and 163: EMISSION UNIT SPECIFIC REQUIREMENTS
Page 188 and 189: II. MONITORING, MAINTENANCE, AND RE
Page 190 and 191: II, MONITORING, MAINTENANCE, AND RE
Page 208 and 209: II. MONITORlNG, MAINTENANCE, AND RE
Page 232 and 233: III. PROHIBITED ACTIVITIESPermit No
Page 234 and 235: IV. ACTIVITIES REQUIRING ADDITIONAL
Page 236 and 237: IV. ACTIVITIES REQUIRING ADDITIONAL
Page 238 and 239: V. STANDARD TERMS AND CONDITIONSPer
Page 242 and 243: v. STANDARD TERMS AND CONDITIONSPer
Page 260 and 261: V. STANDARD TERMS AND CONDITIONSPen
Page 262 and 263:
V. STANDARD TERMS AND CONDITIONSPer
Page 264 and 265:
Page 266 and 267:
Page 268 and 269:
Page 270 and 271:
Page 272 and 273:
Page 274 and 275:
v. STANDARD TERMS AND CONDITIONSPer
Page 276 and 277:
Page 278 and 279:
Page 280 and 281:
VI. PERMIT ACTIONSPermit No. 13120E
Page 282 and 283:
Page 284 and 285:
Page 286 and 287:
Page 288 and 289:
VII. PERMIT SI-IIELDPermit No. 1312
Page 290 and 291:
VIII APPENDIXESPermit No. 13120Expi
show all

Air Operating Permit - Puget Sound Clean Air Agency

Create successful ePaper yourself

Delete template?

Save as template?