Air Operating Permit - Puget Sound Clean Air Agency

II. MONITORING, MAINTENANCE, AND RECORDKEEPING Permit No. 13120Expiration Date: September 12, 2013Page 217 of291o The quantity of VOCs in the VOC-containing materials reported pursuant toPSD-05-02, Condition 8.1. [PSD-05-02, Condition 8.2, 8/25/05]o For VOCs that were deducted pursuant to PSD-05-02, Condition 6.3.1, themonthly and rolling twelve month quantity of reactive VOCs incorporated intothe final, cured airplane coating in each of Paint Hangar Final Exterior Coating,787 Final Assembly, and Interiors Manufacturing. [PSD-05-02, Condition 8.3,8/25/05]o For VOCs that were deducted pursuant to PSD-05-02, Condition 6.3.2, themonthly and rolling twelve month quantity of VOCs recovered for off-siterecycle or disposal or discharged from Boeing Everett to waste water or solidwaste from materials used in Paint Hangar Final Exterior Coating, 787 FinalAssembly, and Interiors Manufacturing. [PSD-05-02, Condition 8.4, 8/25/05](q) Reserved(r) Continuous Emission Monitoring System(i) Opacity, Boiler Nos. 4, 5 and, 6When firing back-up fuel oil, Boeing shall operate and maintain a continuous oxygenemission monitoring system for measuring excess oxygen in the exhaust gas stream,as an alternate means of demonstrating compliance with 40 CFR 60.43(1). Whenfiring back-up fuel oil, Boeing shall maintain excess O 2 at or greater than 2% (6-minute average), except during startup, shutdown, or malfunctions of the boilers.[Order of Approval No. 7438, Condition No. 14]The continuous oxygen emission monitor is required to meet the appropriaterequirements in 40 CFR 60.13, and must be evaluated pursuant to 40 CFR Part 60,Appendix B, Performance 3. In addition, the analyzer shall meet the followingrequirements.a) The oxygen analyzer shall have a span value of25% oxygenb) The calibration drift for the oxygen analyzer shall be measured at 0% oxygenand approximately 21 % oxygen.Boeing-Everett Permit, issued September 12, 2008,' Administrative Amendment 3: October 10, 2012