Air Operating Permit - Puget Sound Clean Air Agency

More documents

Recommendations

Info

EMISSION UNIT SPECIFIC REQUIREMENTSI.B.3 Coating, Cleaning, and Depainting OperationsPermit No. 13120Expiration Date: September 12, 2013Page 32 of291EU 3.1840CFR63.741(b)(9/1198)Boeing must comply with Subparts GG and A, exceptas specified in 40 CFR 63.743(a) and Table I ofSubpartGG.NMREU 3.1940CFR63.741 (a)-(d)(9/1198)Affected sources are specified in 40 CFR 63.74 I (c)(1 )through (7). The activities subject to the AerospaceNESHAP requirements are limited to the manufactureor rework of aerospace vehicles or components asdefined in the regulation. Where a dispute arisesrelating to the applicability of Subpart GG to aspecific activity, Boeing shali demonstrate that theactivity is not regulated under Subpali GG.NMR3 January 15, 1998 letter from Neal Shulman, Puget Sound Clean Air Agency, to David Moore,Boeing.Boeing-Everett Permit, issued September 12, 2008,' Administrative Amendment 3: October 10, 2012
EMISSION UNIT SPECIFIC REQUIREMENTSLB.3 Coating, Cleaning, and Depainting OperationsPermit No. 13120Expiration Date: September 12,2013Page 33 of291EU 3.20 40CFR The Aerospace NESHAP requirements are not NMR63.741(e), (t) applicable to: RCRA hazardous waste, specialty(9/1/98) coatings, adhesives, adhesive bonding primers,sealant, research and development, quality control,laboratory testing activities, chemical milling, metalfinishing, electrodeposition (except of paints),composites processing (except cleaning and coating ofcomposite parts or components that become part of anaerospace vehicle or component as well as compositetooling that comes in contact with such compositeparts or components prior to cure), electronic partsand assemblies (except cleaning and topcoating ofcompleted assemblies), manufacture of aircrafttransparencies, wastewater operations, parts andassemblies not critical to the vehicle's structuralintegrity or flight performance. Not applicable toprimers, topcoats, chemical milling maskants,strippers and cleaning solvents with HAP and VOCJess than 0.1 percent for carcinogens or 1.0 percent fornoncarcinogens as detennined from manufacturer'srepresentations.EU 3. 21 40CFR The requirements for primers, topcoats, and chemical NMR63.741(g) milling maskants in 40 CFR 63.745 and 40 CFR(9/1/98) 63.747 do not apply to the use of low-volume coatingsin these categories for which the annual total of eachseparate formulation used at a facility does not exceed189 liter (L) (50 gallons [gal]), and the combinedannual total of all such primers, topcoats, andchemical milling maskants used at a facility does notexceed 757 L (200 gal).EU 3. 22 40 CFR Regulated activities associated with space vehicles are NMR63.741(h) exempt from the requirements of the Aerospace(911/98) NESHAP, except for depainting operations in 40 CFR63.746.EU 3. 23 40CFR Waterborne coatings are exempt from 40 CFR NMR63.741(i) 63.745(d)-(e), 63.747(d)-(e), 63.749(d) and (h),(9/1/98) 63.750(c)-(h) and (k)-(m), 63.752(c) and (t), and63.753(c) and (e).EU 3. 24 40CFR Aerospace NESHAP does not apply to rework on NMR63.7410) antique vehicles.(9/1/98)Boeing-Everett Permit, issued September 12, 2008,' Administrative Amendment 3: October 10, 2012
Page 1 and 2: AIR OPERATING PERMITpscleanair.orgP
Page 3 and 4: Permit No. 13120Expiration Date: Se
Page 5 and 6: Permit No. 13120Expiration Date: Se
Page 7 and 8: Facility-Wide Applicable Requiremen
Page 16 and 17: PennitNo.13120EMISSION UNIT SPECIFI
Page 18 and 19: EMISSION UNIT SPECIFIC REQUIREMENTS
Page 82 and 83:
EMISSION UNIT SPECIFIC REQUIREMENTS
Page 84 and 85:
Page 86 and 87:
Page 88 and 89:
Page 90 and 91:
Page 92 and 93:
Page 94 and 95:
Page 96 and 97:
Page 98 and 99:
Page 100 and 101:
Page 102 and 103:
Page 104 and 105:
Page 106 and 107:
Page 108 and 109:
Page 110 and 111:
Page 112 and 113:
Page 114 and 115:
Page 116 and 117:
Page 118 and 119:
Page 120 and 121:
Permit No. 13120EMISSION UNIT SPECI
Page 122 and 123:
Page 124 and 125:
Page 126 and 127:
Page 128 and 129:
Page 130 and 131:
Page 132 and 133:
Page 134 and 135:
Page 136 and 137:
Page 138 and 139:
Page 140 and 141:
Page 142 and 143:
Page 144 and 145:
Page 146 and 147:
Page 148 and 149:
Page 150 and 151:
Page 152 and 153:
Page 154 and 155:
Page 156 and 157:
Page 158 and 159:
Page 160 and 161:
Page 162 and 163:
Page 164 and 165:
Page 166 and 167:
Page 168 and 169:
Page 170 and 171:
Page 172 and 173:
Page 174 and 175:
Page 176 and 177:
Page 178 and 179:
Page 180 and 181:
Page 182 and 183:
Page 184 and 185:
Page 186 and 187:
Page 188 and 189:
II. MONITORING, MAINTENANCE, AND RE
Page 190 and 191:
II, MONITORING, MAINTENANCE, AND RE
Page 192 and 193:
Page 194 and 195:
Page 196 and 197:
Page 198 and 199:
Page 200 and 201:
Page 202 and 203:
Page 204 and 205:
Page 206 and 207:
Page 208 and 209:
II. MONITORlNG, MAINTENANCE, AND RE
Page 210 and 211:
Page 212 and 213:
II. MONITORfNG, MAINTENANCE, AND RE
Page 214 and 215:
Page 216 and 217:
Page 218 and 219:
Page 220 and 221:
Page 222 and 223:
Page 224 and 225:
Page 226 and 227:
Page 228 and 229:
Page 230 and 231:
Page 232 and 233:
III. PROHIBITED ACTIVITIESPermit No
Page 234 and 235:
IV. ACTIVITIES REQUIRING ADDITIONAL
Page 236 and 237:
IV. ACTIVITIES REQUIRING ADDITIONAL
Page 238 and 239:
V. STANDARD TERMS AND CONDITIONSPer
Page 240 and 241:
Page 242 and 243:
v. STANDARD TERMS AND CONDITIONSPer
Page 244 and 245:
Page 246 and 247:
Page 248 and 249:
Page 250 and 251:
Page 252 and 253:
Page 254 and 255:
Page 256 and 257:
Page 258 and 259:
Page 260 and 261:
V. STANDARD TERMS AND CONDITIONSPen
Page 262 and 263:
Page 264 and 265:
Page 266 and 267:
Page 268 and 269:
Page 270 and 271:
Page 272 and 273:
Page 274 and 275:
v. STANDARD TERMS AND CONDITIONSPer
Page 276 and 277:
Page 278 and 279:
Page 280 and 281:
VI. PERMIT ACTIONSPermit No. 13120E
Page 282 and 283:
Page 284 and 285:
Page 286 and 287:
Page 288 and 289:
VII. PERMIT SI-IIELDPermit No. 1312
Page 290 and 291:
VIII APPENDIXESPermit No. 13120Expi
show all

Air Operating Permit - Puget Sound Clean Air Agency

Create successful ePaper yourself

Delete template?

Save as template?