Air Operating Permit - Puget Sound Clean Air Agency

EMISSION UNIT SPECIFIC REQUIREMENTSLB.3 Coating, Cleaning, and Depainting OperationsPermit No. 13120Expiration Date: September 12, 2013Page 92 of291Puget SoundClean AirAgency RegI: 9.16 (b)(2/22/07)(State Only)are exempt from theprovisions of Reg I: 9.16(c) and (d). Persons claimingany of the exemptions shall have the burden ofdemonstrating compliance:I) Application of architectural or maintenancecoatings to stationary structures.2) Aerospace coating operations subject to 40 CFRPart 63 Subpart GG, including all activities andmaterials listed in 40 CFR 63.741(1).3) Use of HVLP guns in celiain situations describedin Reg I: 9.16(b)(3)(A) through (E).4) Use of air brush spray equipment with 0.5 to 2.0CFM airflow and 2 fluid ounce or less cup capacity.5) Use of hand-held aerosol spray cans with 1 quartor less capacity.6) Indoor application of automotive undercoatingmaterials using organic solvents with flash points inexcess of 100F.For the flightline, buildings 40-21 - 40-26, and 40-31 -40-36, items that cannot be reasonably handled in anenclosed spray area are exempt from Regulation I,Section 9.1 10Unlawful to allow spray-coating inside a structure, orspray-coating of any motor vehicles or components,unless the spray-coating is conducted inside anenclosed spray area employing paint arresters orwater-wash curtains to control overspray. Allemissions shall be vented through an unobstructedvertical exhaust vent.NMREU 3. 224Puget SoundClean AirAgency RegI: 9.16(c)(2/22/07)[LA.I(c)FacilityInspectionsBooths 701500 and B056 in the 40-31 and 45-01 areexempt from the vertical stack requirements. II10 November 30, 1992 letter from David Kircher, Puget Sound Clean Air Agency, to B.J Thompson, Boeing. May30, 1995 letter from Jay Willenberg, Puget Sound Clean Air Agency, to B.J. Thompson, Boeing.II December 3, 1998 letter from David Kircher, Puget Sound Clean Air Agency, to Frank Migaiolo, Boeing.Boeing-Everett Permit, issued September 12, 2008; Administrative Amendment 3: October 10,2012