Air Operating Permit - Puget Sound Clean Air Agency

More documents

Recommendations

Info

EMISSION UNIT SPECIFIC REQUIREMENTSLB.3 Coating, Cleaning, and Depainting OperationsPermit No. 13120Expiration Date: September 12,2013Page 90 of 291EU 3. 215 Order of The air from the spray booth shall exhaust through a n.A.2( d)(ii) 319Approval No. dry filter with a removal efficiency greater than or Spray Booths9705 equal to the efficiency in 40 CFR 63.745(g)(2)(ii)(A). and OtherConditionPmiiculateNo.3Control(11/19/07) BoothsEU 3.216 Order of Boeing shall install and maintain a gauge to measure II.A.2( d)(ii)Approval No. the pressure drop across the spray booth exhaust filters Spray Booths9705 and mark the acceptable range for the gauge on or and OtherCondition near the gauge, or on a pressure drop log. ParticulateNo.4Control(11/19/07) BoothsEU 3.217 Order of Boeing shall record if the pressure drop across the II.A.2(d)(ii)Approval No. exhaust filters is in the acceptable range at least Spray Booths9705 weekly when the spray booth is used, and once each and OtherCondition shift that the spray booth is used for Aerospace ParticulateNo.5 NESHAP affected spray coating operations as Control(11/19/07) required by 40 CFR 63.745(g), unless using coatings Boothswith inorganic HAP concentrations of less than 0.1percent for carcinogens and 1.0 percent for non- n.A.2(i)carcinogens.AerospaceNESHAPFor any shifts when spray coating operations occurred Pressureand pressure drop readings were not recorded, Boeingshall document the regulatory status of the coating.Drop/WaterFlow RateMonitoringandRecordkeepingProcedureEU 3. 218 Order of If the pressure drop is not within the acceptable range, n.B OperationApproval No. corrective actions shall be taken prior to resuming any and9705 spray coating activity in this spray booth. MaintenanceCondition(O&M) PlanNo.6Requirements.(11/19/07)Boeing-Everett Permit, issued September 12, 2008,' Administrative Amendment 3: October 10, 2012
EMISSION UNIT SPECIFIC REQUIREMENTSLB.3 Coating, Cleaning, and Depainting OperationsPermit No. 13120Expiration Date: September 12, 2013Page 91 of291EU 3. 219Order ofApproval No.9705ConditionNo.9(I IiI 9i07)Spray coating operations shall be conducted usinghigh volume low pressure (HVLP), hand-held spraycans, or airbrush.II.A.l(d) WorkPracticeInspectionEU3.220 RCW70.94.152(7)1996 (StateOnly)Maintain equipment that has received an Order ofApproval in good working orderII.A.2( d)(ii)Spray Boothsand OtherParticulateControlBoothsEU 3. 221Puget SoundClean AirAgency RegIll: 2:02(9/26/02)(State Only)Adopts 40 CFR 63 by reference and thoserequirements are listed elsewhere in this permit.NMREU 3. 222 Puget SoundClean Ail'Agency RegI: 9.16(a)(2/22/07)(State Only)The regulation applies to spray coating operations atBoeing Everett where coating that protects orbeautifies a surface is applied with spray coatingequipment.NMRBoeing-Everett Permit, issued September 12, 2008; Administrative Amendment 3: October 10,2012
Page 1 and 2:
AIR OPERATING PERMITpscleanair.orgP
Page 3 and 4:
Permit No. 13120Expiration Date: Se
Page 5 and 6:
Permit No. 13120Expiration Date: Se
Page 7 and 8:
Facility-Wide Applicable Requiremen
Page 9 and 10:
Page 11 and 12:
Page 14 and 15:
Page 16 and 17:
PennitNo.13120EMISSION UNIT SPECIFI
Page 18 and 19:
EMISSION UNIT SPECIFIC REQUIREMENTS
Page 20 and 21:
Page 22 and 23:
Page 24 and 25:
Page 26 and 27:
Page 28 and 29:
Page 30 and 31:
Page 32 and 33:
Page 34 and 35:
Page 36 and 37:
Page 38 and 39:
Page 40 and 41: EMISSION UNIT SPECIFIC REQUIREMENTS
Page 120 and 121: Permit No. 13120EMISSION UNIT SPECI
Page 140 and 141:
Page 142 and 143:
Page 144 and 145:
Page 146 and 147:
Page 148 and 149:
Page 150 and 151:
Page 152 and 153:
Page 154 and 155:
Page 156 and 157:
Page 158 and 159:
Page 160 and 161:
Page 162 and 163:
Page 164 and 165:
Page 166 and 167:
Page 168 and 169:
Page 170 and 171:
Page 172 and 173:
Page 174 and 175:
Page 176 and 177:
Page 178 and 179:
Page 180 and 181:
Page 182 and 183:
Page 184 and 185:
Page 186 and 187:
Page 188 and 189:
II. MONITORING, MAINTENANCE, AND RE
Page 190 and 191:
II, MONITORING, MAINTENANCE, AND RE
Page 192 and 193:
Page 194 and 195:
Page 196 and 197:
Page 198 and 199:
Page 200 and 201:
Page 202 and 203:
Page 204 and 205:
Page 206 and 207:
Page 208 and 209:
II. MONITORlNG, MAINTENANCE, AND RE
Page 210 and 211:
Page 212 and 213:
II. MONITORfNG, MAINTENANCE, AND RE
Page 214 and 215:
Page 216 and 217:
Page 218 and 219:
Page 220 and 221:
Page 222 and 223:
Page 224 and 225:
Page 226 and 227:
Page 228 and 229:
Page 230 and 231:
Page 232 and 233:
III. PROHIBITED ACTIVITIESPermit No
Page 234 and 235:
IV. ACTIVITIES REQUIRING ADDITIONAL
Page 236 and 237:
IV. ACTIVITIES REQUIRING ADDITIONAL
Page 238 and 239:
V. STANDARD TERMS AND CONDITIONSPer
Page 240 and 241:
Page 242 and 243:
v. STANDARD TERMS AND CONDITIONSPer
Page 244 and 245:
Page 246 and 247:
Page 248 and 249:
Page 250 and 251:
Page 252 and 253:
Page 254 and 255:
Page 256 and 257:
Page 258 and 259:
Page 260 and 261:
V. STANDARD TERMS AND CONDITIONSPen
Page 262 and 263:
Page 264 and 265:
Page 266 and 267:
Page 268 and 269:
Page 270 and 271:
Page 272 and 273:
Page 274 and 275:
v. STANDARD TERMS AND CONDITIONSPer
Page 276 and 277:
Page 278 and 279:
Page 280 and 281:
VI. PERMIT ACTIONSPermit No. 13120E
Page 282 and 283:
Page 284 and 285:
Page 286 and 287:
Page 288 and 289:
VII. PERMIT SI-IIELDPermit No. 1312
Page 290 and 291:
VIII APPENDIXESPermit No. 13120Expi
show all

Air Operating Permit - Puget Sound Clean Air Agency

You also want an ePaper? Increase the reach of your titles

Delete template?

Save as template?