Specs

More documents

Recommendations

Info

Bridgestone Retail Operations, LLC PROJECT MANUAL Version: January 2012 C. The heater's burner shall consist of a heavy-duty cast iron atmospheric burner. The flame characteristics shall be highly luminous for maximum radiant heat transfer through the emitter tube wall. D. The heater's emitter tube shall operate at an average surface temperature of 700ºF - 800ºF and shall be made of 16-gauge calorized aluminized steel or calorized titanium alloy Alumi-Therm steel for long life (4" O.D.). The emitter tube shall be calorized for longevity, corrosion resistance, and high radiant efficiency. The measured surface emissivity shall be 0.83 - 0.86 at operating temperature. The calorization process shall produce an emitter tube that is highly radiant absorptive (0.95) on the interior and highly radiant emissive (0.83-0.86) on the exterior. The system shall have a radiant efficiency (or radiant coefficient) of 58%. E. To assure a high degree of safety and increased radiant efficiency, the heaters shall operate under negative pressure at all times during operation to preclude the escape of combustion gases inside the building. The heater exhaust assembly shall include a 120-volt draft inducer. The draft inducer shall be equipped with a permanently lubricated, totally enclosed and shielded, fan cooled, and heavy-duty ball bearing motor. The motor shall not require maintenance or lubrication for the life of the unit. The draft inducer assembly shall be capable of rotating 90º for vertical or horizontal venting. F. The heaters will be CSA design certified for vertical or horizontal venting, maximum 75 feet horizontal sidewall venting, and for 50 feet outside combustion air inlet duct. There shall be no draft hoods. The combustion chamber shall be totally enclosed. G. The heaters shall be factory assembled and tested. The heaters shall not require any field adjustments to assure maximum performance and safety. Heaters shall operate satisfactorily in any position from horizontal to forty-five degrees (45º) from horizontal, and incline mounted up to 2/12 pitch, and shall be suitable for vented/indirect vented applications. Heaters shall be designed to operate on natural or propane gas. 2.03 CONTROLS A. Thermostat: Devices and wiring are specified in Division 15 Section "HVAC Instrumentation and Controls." PART 3 - EXECUTION 3.01 INSTALLATION A. Install and connect gas-fired radiant heaters and associated fuel and vent features and systems according to NFPA 54, applicable local codes and regulations, and manufacturer's written installation instructions. B. Suspended Units: Suspend from substrate using manufacturer’s suspension kits. C. Maintain manufacturers' recommended clearances to combustibles. D. Install piping adjacent to gas-fired radiant heaters to allow service and maintenance. E. Gas Piping: Comply with Division 15 Section "Fuel Gas Piping." Connect gas piping to gas train inlet; provide union with enough clearance for burner removal and service. F. Vent Connections: Comply with Division 15 Section "Breechings, Chimneys, and Stacks." G. Electrical Connections: Comply with applicable requirements in Division 16 Sections. 1. Install electrical devices furnished with heaters but not specified to be factory mounted. GAS-FIRED RADIANT HEATERS 15542 - Page 3 of 4
Bridgestone Retail Operations, LLC H. Adjust initial temperature set points. PROJECT MANUAL Version: January 2012 I. Adjust burner and other unit components for optimum heating performance and efficiency. 3.02 FIELD QUALITY CONTROL A. Tests and Inspections: Test and adjust controls and safeties. Replace damaged and malfunctioning controls and equipment. END OF SECTION GAS-FIRED RADIANT HEATERS 15542 - Page 4 of 4
Page 1:
Bridgestone Retail Operations, LLC
Page 5 and 6:
Bismarck Real Estate Partners, Inc.
Page 7 and 8:
Bismarck Real Estate Partners, Inc.
Page 9 and 10:
Page 11 and 12:
Page 13:
Page 16 and 17:
Page 18 and 19:
Page 21 and 22:
Page 23 and 24:
Page 28 and 29:
Page 30 and 31:
Page 32 and 33:
Page 34 and 35:
Page 36 and 37:
Bridgestone Retail Operations LLC..
Page 38 and 39:
Page 40 and 41:
Page 42 and 43:
Page 44 and 45:
Page 46 and 47:
Page 48 and 49:
Page 50 and 51:
Page 52 and 53:
Page 54 and 55:
Page 56 and 57:
Page 58 and 59:
Page 60 and 61:
Page 62 and 63:
Page 64 and 65:
Page 66 and 67:
Page 68 and 69:
Page 70 and 71:
Page 72 and 73:
Page 74 and 75:
Page 76 and 77:
Page 78 and 79:
Page 80 and 81:
Page 82 and 83:
Page 84 and 85:
Page 86 and 87:
Page 88 and 89:
Page 90 and 91:
Page 92 and 93:
Page 94 and 95:
Page 96 and 97:
Page 98 and 99:
Page 100:
Page 103 and 104:
Page 106 and 107:
Page 108 and 109:
Page 110 and 111:
Page 112 and 113:
Page 114 and 115:
Page 116 and 117:
Page 118 and 119:
Page 120 and 121:
Page 122 and 123:
Page 124 and 125:
Page 126 and 127:
Page 128:
Page 131 and 132:
Page 133 and 134:
Page 135 and 136:
Page 138 and 139:
Page 140 and 141:
Page 142 and 143:
Page 144 and 145:
Page 146:
Page 149 and 150:
Page 152 and 153:
Page 154 and 155:
Page 156 and 157:
Page 158 and 159:
Page 160 and 161:
Page 162:
Page 165 and 166:
Page 168:
Page 172 and 173:
Page 174 and 175:
Page 176:
Page 180 and 181:
Page 182 and 183:
Page 184 and 185:
Page 186 and 187:
Page 188 and 189:
Page 190:
Page 193 and 194:
Page 195 and 196:
Page 197 and 198:
Page 199 and 200:
Page 202 and 203:
Page 204 and 205:
Page 206 and 207:
Page 208 and 209:
Page 210 and 211:
Page 212:
Page 215 and 216:
Page 217 and 218:
Page 219 and 220:
Page 221 and 222:
Page 223 and 224:
Page 225 and 226:
Page 228 and 229:
Page 230 and 231:
Page 232 and 233:
Page 234 and 235:
Page 236 and 237:
Page 238:
Page 241 and 242:
Page 244 and 245:
Page 246 and 247:
Page 248:
Page 251 and 252:
Page 253 and 254:
Page 255 and 256:
Page 257 and 258:
Page 259 and 260:
Page 262 and 263:
Page 264:
Page 267 and 268:
Bridgestone Retail Operations LLC P
Page 270 and 271:
Page 272 and 273:
Page 274:
Page 277 and 278:
Page 280 and 281:
Page 282:
Page 285 and 286:
Page 287 and 288:
Page 289 and 290:
Page 292:
Page 296 and 297:
Page 298:
Page 301 and 302:
Page 303 and 304:
Page 305 and 306:
Page 308 and 309:
Page 310 and 311:
Page 312:
Page 315 and 316:
Page 317 and 318:
Page 320 and 321:
Page 322:
Page 325 and 326:
Page 328 and 329:
Page 330:
Page 333 and 334:
Page 336 and 337:
Page 338 and 339:
Page 340:
Page 343 and 344:
Page 345 and 346:
Page 347 and 348:
Page 349 and 350:
Page 351 and 352:
Page 353 and 354:
Page 356 and 357:
Page 358 and 359:
Page 360:
Page 363 and 364:
Page 366 and 367:
Page 368 and 369:
Page 370 and 371:
Page 372 and 373:
Page 374 and 375:
Page 376 and 377:
Page 378 and 379:
Page 380 and 381:
Page 382 and 383:
Page 384 and 385:
Page 386:
Page 389 and 390:
Page 391 and 392:
Page 393 and 394:
Page 395 and 396:
Page 397 and 398:
Page 399 and 400:
Page 402 and 403:
Page 404 and 405:
Page 406 and 407:
Page 408 and 409:
Page 410 and 411:
Page 412 and 413:
Page 414 and 415:
Page 416:
Page 419 and 420:
Page 422 and 423:
Page 424 and 425:
Page 426 and 427:
Page 428:
Page 431 and 432:
Page 433 and 434:
Page 436 and 437:
Page 438 and 439:
Page 440 and 441:
Page 442 and 443: Bridgestone Retail Operations, LLC
Page 460: Bridgestone Retail Operations, LLC
Page 542:
Page 546:
Page 549 and 550:
Page 552 and 553:
Page 554:
Page 558:
Page 562 and 563:
Page 564 and 565:
Page 566:
Page 570 and 571:
Page 572 and 573:
Page 574 and 575:
Page 576 and 577:
Page 578 and 579:
Page 580 and 581:
Page 582:
Page 585 and 586:
Page 587 and 588:
Page 589:
Page 592 and 593:
REPORT OF GEOTECHNICAL ENGINEERING
Page 594 and 595:
Proposed Bridgestone April 20, 2011
Page 596 and 597:
Page 598 and 599:
Page 600 and 601:
Page 602 and 603:
Page 604 and 605:
Page 606 and 607:
Page 608 and 609:
Page 611 and 612:
FIGURE: 3 DATE STARTED: 4/5/11 DRIL
Page 613 and 614:
Page 615 and 616:
Page 617 and 618:
Page 619 and 620:
FIGURE: 11 DATE STARTED: 4/5/11 DRI
Page 621 and 622:
APPENDIX A Laboratory Test Results
Page 623 and 624:
12 SWELL-CONSOLIDATION TEST 10 8 6
Page 625 and 626:
Page 627 and 628:
Page 629 and 630:
Page 631 and 632:
10 SWELL-CONSOLIDATION TEST 8 6 4 2
Page 633 and 634:
Page 635 and 636:
Page 637 and 638:
Page 639 and 640:
June 21, 2012 Bridgestone Retail Op
Page 641 and 642:
Bridgestone/Firestone - Lakewood, C
Page 643 and 644:
Bridgestone/Firestone - Lakewood, C
show all

Specs

You also want an ePaper? Increase the reach of your titles

Delete template?

Save as template?