Rexroth IndraDrive C Drive Controllers HCS02.1 ... - Bosch Rexroth

More documents

Recommendations

Info

6-56 Mounting and Installation Rexroth IndraDrive Design Tightening Torque DC Bus Wiring DC Bus (L+, L-) By means of the DC bus connection, the following components are linked: • several drive controllers to one another, and • drive controllers to additional components in order to • increase the stored power by means of DC bus capacitor unit • increase the permissible braking resistor continuous output by means of DC bus resistor unit The DC bus is connected via contact bars and screws (M6) at the front of the drive controller. Depending on the width of the drive controllers, there are contact bars of different lengths. 6 Nm If in special cases it is not possible to use the DC bus rails for connection, connection must be established using the shortest possible twisted wires. Length of twisted wire HCS02: max. 2 m HCS03: max. 4 m Wire cross section min. 10 mm², but not less than supply feeder cross section Wire protection by means of fuses in the mains supply Dielectric strength of single strand against ground CAUTION > 750 V (e.g.: strand type - H07) Damage caused by voltage arcing! ⇒ If drive controllers are stacked in the control cabinet, the connections for the DC buses between the drive controllers have to be correctly made. The figures below illustrate the correct DC bus connection for stacked drive controllers. The illustrated way of connection keeps bare wire sections from being situated directly vis-à-vis. This avoids voltage arcing. The cables have to be twisted. CAUTION Risk of damage! ⇒ Connect the devices both to the left and to the right screw connection at the terminal block. DOK-INDRV*-FU*********-IB01-EN-P
Rexroth IndraDrive Mounting and Installation 6-57 DOK-INDRV*-FU*********-IB01-EN-P Cable Routing to the Left: CAUTION device 1 (DC bus connection) device 2 (DC bus connection) Damage caused by voltage arcing! ⇒ Insulate ring terminals and connecting lines with a heat-shrinkable sleeve. Afterwards only strip the insulation of the contact surface of the ring terminal. Realize connections according to figure. device 1 (DC bus connection) device 2 (DC bus connection) correct incorrect Fig. 6-80: DC bus connections for cable routing to the left DC bus nach links_1f4
Page 1 and 2:
Electric Drives Linear Motion and a
Page 3 and 4:
Rexroth IndraDrive Contents I Conte
Page 5 and 6:
Rexroth IndraDrive Contents III Mul
Page 7 and 8:
Rexroth IndraDrive Introducing the
Page 9 and 10:
Page 11 and 12:
Page 13 and 14:
Page 15 and 16:
Page 17 and 18:
Page 19 and 20:
Page 21 and 22:
Page 23 and 24:
Page 25 and 26:
Page 27 and 28:
Rexroth IndraDrive Important Direct
Page 29 and 30:
Rexroth IndraDrive Safety Instructi
Page 31 and 32:
Page 33 and 34:
Page 35 and 36:
Page 37 and 38:
Page 39 and 40:
Page 41 and 42:
Rexroth IndraDrive Identification,
Page 43 and 44:
Page 45 and 46:
Page 47 and 48:
Page 49 and 50:
Page 51 and 52:
Rexroth IndraDrive Electrical Data
Page 53 and 54:
Page 55 and 56:
Page 57 and 58:
Page 59 and 60:
Page 61 and 62:
Page 63 and 64:
Page 65 and 66:
Page 67 and 68:
Page 69 and 70:
Page 71 and 72:
Page 73 and 74:
Page 75 and 76:
Page 77 and 78:
Rexroth IndraDrive Mounting and Ins
Page 79 and 80:
Rexroth IndraDrive Mounting and Ins
Page 81 and 82: Rexroth IndraDrive Mounting and Ins
Page 131: Rexroth IndraDrive Mounting and Ins
Page 163 and 164: Rexroth IndraDrive Commissioning an
Page 183 and 184:
Rexroth IndraDrive Commissioning an
Page 185 and 186:
Page 187 and 188:
Page 189 and 190:
Page 191 and 192:
Page 193 and 194:
Page 195 and 196:
Page 197 and 198:
Page 199 and 200:
Page 201 and 202:
Page 203 and 204:
Page 205 and 206:
Page 207 and 208:
Page 209 and 210:
Page 211 and 212:
Page 213 and 214:
Page 215 and 216:
Page 217 and 218:
Page 219 and 220:
Page 221 and 222:
Page 223 and 224:
Page 225 and 226:
Page 227 and 228:
Page 229 and 230:
Page 231 and 232:
Page 233 and 234:
Page 235 and 236:
Page 237 and 238:
Page 239 and 240:
Page 241 and 242:
Page 243 and 244:
Page 245 and 246:
Page 247 and 248:
Page 249 and 250:
Page 251 and 252:
Page 253 and 254:
Page 255 and 256:
Page 257 and 258:
Page 259 and 260:
Page 261 and 262:
Page 263 and 264:
Page 265 and 266:
Page 267 and 268:
Page 269 and 270:
Page 271 and 272:
Page 273 and 274:
Page 275 and 276:
Page 277 and 278:
Page 279 and 280:
Page 281 and 282:
Page 283 and 284:
Page 285 and 286:
Page 287 and 288:
Page 289 and 290:
Page 291 and 292:
Page 293 and 294:
Page 295 and 296:
Page 297 and 298:
Page 299 and 300:
Page 301 and 302:
Rexroth IndraDrive Diagnostic and S
Page 303 and 304:
Page 305 and 306:
Page 307 and 308:
Page 309 and 310:
Page 311 and 312:
Page 313 and 314:
Page 315 and 316:
Page 317 and 318:
Page 319 and 320:
Page 321 and 322:
Page 323 and 324:
Page 325 and 326:
Page 327 and 328:
Page 329 and 330:
Page 331 and 332:
Page 333 and 334:
Page 335 and 336:
Page 337 and 338:
Page 339 and 340:
Rexroth IndraDrive Service & Suppor
Page 341 and 342:
Page 343 and 344:
Page 345 and 346:
Rexroth IndraDrive Index 10-1 10 In
Page 347 and 348:
Rexroth IndraDrive Index 10-3 DOK-I
Page 349 and 350:
Page 351 and 352:
Page 353 and 354:
Page 355 and 356:
Rexroth IndraDrive Index 10-11 DOK-
Page 358:
R911314905 Bosch Rexroth AG Electri
show all

Rexroth IndraDrive C Drive Controllers HCS02.1 ... - Bosch Rexroth

You also want an ePaper? Increase the reach of your titles

Delete template?

Save as template?